Napoleon-grills LD485RB Manuel d'utilisateur Page 1

Napoleon Appliance Corp.,214 Bayview Dr., Barrie, Ontario, Canada L4N 4Y8 Phone: 1-866-820-8686Fax: (705)725-2564 email: [email protected]

10 www.napoleongrills.comof the burner. Shake any loose debris from the burner through the gas inlet. Check the burner ports and valve orices for bl

11www.napoleongrills.comProblem Possible Causes SoluonFlames li away from burner, accompanied by the smell of gas, and possibly dicules in lighn

12 www.napoleongrills.comKEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE YOUR WARRANTY.Ordering Replacement PartsWarranty InformaonMODEL:DATE OF

13www.napoleongrills.comCAUTION! During unpacking and assembly we recommended you wear work gloves and safety glasses for your protecon. Although w

14 www.napoleongrills.com2. Caster/Bracket InstallaonAach (4) casters, using (4) ¼ -20 x 3/8” screws and (4) ¼ -20 lock nuts for each caster. Aac

15www.napoleongrills.comPropane Only4 x N570-0080 (#14 x 1/2”)3/8”(10mm)3. Propane Tank Ring Installaon Insert propane tank ring into slots in boom

16 www.napoleongrills.com6 x N570-0080 (#14 x 1/2”)3/8”(10mm)5. Rear Cart Panel InstallaonFit rear cart panel between the two end panels; ensure lar

17www.napoleongrills.com6. Tank Inhibitor Bracket / Propane Tank Mount InstallaonInsert tank inhibitor bracket into slot in rear panel as illustrate

18 www.napoleongrills.com4 x N570-0080 (#14 x 1/2”)3/8”(10mm)4 x N570-0080 (#14 x 1/2”)1 X N430-00027. Front Cabinet Support InstallaonFasten top ra

19www.napoleongrills.com4 x N570-0091 (1/4-20 X 1/2”)3/8”(10mm)Correct AssemblyIncorrect Assembly9. Grill Head InstallaonPROPANE ONLY – To avoid ass

2 www.napoleongrills.comNapoleon Gas Grill President’s Limited Warranty NAPOLEON warrants the following materials and workmanship in your new NAPOLEO

20 www.napoleongrills.com3/8”(10mm)2 x N570-0073 (1/4-20 X 3/8”)10. Rosserie Mount Installaon Install rosserie mount bracket to le side of barbec

21www.napoleongrills.com8 x N570-0076 (#8 X 1/2”)11. Side Shelf AssemblyPeel the protecve coang from the side shelf. Insert the top of the side s

22 www.napoleongrills.com4 x N570-0082 (1/4-20 X 5/8”)3/8”(10mm)4 x N735-0001 (insulated washer)12. Side Shelf InstallaonInsert (4) 1/4 - 20 x 5/8”

23www.napoleongrills.com4 x N570-0099 (#14 x 3/4”)3/8”(10mm)4 x N340-0007 (tool hook)13. Door AssemblyInstall the door handle onto the front of the

24 www.napoleongrills.com2 x N160-0022 (pivot pin clip)2 x N105-0011 (door bushing)Bushing1214. Cabinet Door InstallaonFirst direct the pivot pin i

25www.napoleongrills.com15. Sear Plate InstallaonInsert sear plates into base, posion one over each tube burner with slots down to allow drippings

26 www.napoleongrills.com17. Grease Tray and Holder InstallaonClip the wire grease tray holder into the two holes located in the center of the back

27www.napoleongrills.comRosserie Kit Assembly Instrucon(oponal)Assemble rosserie kit components as shown.Ensure stop bushing is ghtened on the i

28 www.napoleongrills.comPropane Only – Proper Hose ConneconWARNING – FIRE HAZARD The regulator must be aached so that no part of the hose touches

29www.napoleongrills.comNatural Gas Only – Proper Hose Connecon3/4”(19mm)WARNING! The installaon must be performed by a licensed gas er, and all

3www.napoleongrills.comWARNING! Failure to follow these instrucons could result in property damage, personal injury or death. Read and follow all w

30 www.napoleongrills.comNatural Gas Only – Improper Hose ConneconWARNING – FIRE HAZARD WARNING! Do not route hose over top of rear panel.WARNING! D

31www.napoleongrills.comLeak Tesng InstruconsWARNING! A leak test must be performed annually and each me a cylinder is hooked up or if a part of

32 www.napoleongrills.comItem Part # Descripon 485RB1 N135-0038G lid side casng le x2 N135-0039G lid side casng right x3 N335-0050 stainless ste

33www.napoleongrills.comParts ListItem Part # Descripon 485RB48 N475-0183-GY1SG le/right side panel cabinet enclosure x49 N160-0014 grease tray hol

34 www.napoleongrills.com

35www.napoleongrills.comFAX TO: 705 727 4282CONTACT NAME:______________________________________________________________________SHIP TO :_____________

36 www.napoleongrills.comNOTES

4 www.napoleongrills.comCylinder Specicaon/Gas Hook UpThis gas barbecue is cered under Canadian and American Naonal Standards, CSA 1.6-2008 and

5www.napoleongrills.comNatural Gas Hook-UpThis natural gas grill is supplied with a 10 supply hose (complete with a quick disconnect) designed for n

6 www.napoleongrills.comLighng InstruconsO PosionWARNING! Open lidWARNING! Ensure all burner controls are in the o posion. Turn on the gas supp

7www.napoleongrills.comOperang The GrillInial Lighng: When lit for the rst me, the gas grill emits a slight odor. This is a normal temporary con

8 www.napoleongrills.comWARNING! Always wear protecve gloves and safety glasses when cleaning your grill.WARNING! To avoid the possibility of burns,

9www.napoleongrills.comTube Burner: The burners are made from heavy wall 304 stainless steel, but extreme heat and a corrosive environment can cause